|
If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
Datasheet File OCR Text: |
TFS 44E.doc Version 1.1 22.03.2002 VI TELEFILTER Filter specification TFS 44E 1/5 1. Measurement condition : 23 C 0 dBm. for input: 50 for output: 50 Ambient temperature TA: Input power level: Terminating impedances at fc : 0 pF. 0 pF. 2. Characteristics : Remark: Reference level for the relative attenuation arel of the TFS 44E is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae . The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 20 dB filter attenuation level relative to the insertion loss ae . The nominal frequency f N is fixed at 44 MHz without tolerance. The temperature coefficient of frequency Tcf is valid both for the reference frequency fc and the frequency response of the filter. All specified parameters have to be reached in the operating temperature range ( OTR ) . Data Insertion loss (Reference level) Nominal frequency : ae fN at temperature TO = 30C typ. value 21 dB 44,000 MHz 44,019 MHz tolerance / limit max. 24 dB 44 MHz Centre frequency fc at ambient temperature TA (fCAT) Pass band ( PB ) at OTR : 0C ... 60C : Amplitude ripple in PB (p-p) : Bandwidth 0,4 dB 1 dB 3 dB 10 20 30 40 dB dB dB dB at OTR : 0C ... 60C : at ambient temperature TA (fCAT) : fN - 2,48 MHz ... fN + 2,48 MHz 0,2 dB max. 0,4 dB 5,70 6,03 6,51 7,22 7,72 8,02 8,21 MHz MHz MHz MHz MHz MHz MHz min. min. 5,16 6,20 MHz MHz max. 8,30 MHz Bandwidth 0,4 dB - band width 3 dB - band width 30 dB - band width Relative attenuation fN fN fN 2,48 4,25 5 arel at OTR : 0C ... 60C 2,48 MHz 3,0 MHz 5 26 MHz MHz 5,50 6,31 8,22 0,25 2,5 45 45...55 1,50 35 2 MHz MHz MHz dB dB dB dB s ns min. min. max. max. max. min. min. max. 4,96 6,00 8,50 0,4 3,0 30 40 90 MHz MHz MHz dB dB dB dB ns fN ..... fN MHz ... fN MHz ... fN MHz ... fN Group delay ( mean value in PB ): Group delay ripple in PB (p-p): Phase ripple in PB (p-p): Temperature coefficient of frequency ( Tc f ) Frequency deviation of fc over temperature Operating temperature ( OTR ) : Storage temperature range -75 ppm/K fc(Hz) = Tcf(ppm/K) x (T - TA) x fCAT (MHz) 0C ... + 60 C - 25 C ... + 85 C Generated: Checked/Approved: Dunzow W. Dr. Bert Wall VI TELEFILTER Potsdamer Strae 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: tft@telefilter.com Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: vti@vtinh.com VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS 44E.doc Version 1.1 22.03.2002 VI TELEFILTER 3. Construction and pin connection 24.64 Filter specification ( all dimensions in mm) pin grid 1,91 mm TFS 44E 2/5 TFS 44E P22 Date-code 9.00 Date-code: M N P ... Year+week 2000 2001 2002 ... 2.62 Max 1.02 1 2 3 4 5 11 Pin 10 Pin 1 Pin 5 Pin 6 Pin 2-4, 7-9 2.31 Input Input RF Return Output Output RF Return Package Ground 10 4.83 x 3.53 1.91 9 8 7 6 1.02 4. 50 matching networks ( please refer to the application note for further details ) : For final test we use scheme 1. 1 2 3 4 5 50 10 9 8 7 6 50 Scheme 1. VI TELEFILTER Potsdamer Strae 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: tft@telefilter.com Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: vti@vtinh.com VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS 44E.doc Version 1.1 22.03.2002 VI TELEFILTER 5. Stability characteristics : Filter specification TFS 44E 3/5 After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 18 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 -55 C to 125C / 30 min. each / 10 cycles DIN IEC 68 part 2 - 14 Test N 2. Vibration: 3. Change of temperature: 4. Resistance to solder heat (reflow): reflow possible: twice max.; for temperature conditions, please refer to the attached "Air reflow temperature conditions" on page 4; 6. Packing : Tape & Reel: DIN IEC 286 - 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: Trailer 1000 min 300 mm min 500 mm min 300 mm Tape (all dimensions in mm) W Po Do E So P2 P1 D1(min) Ao Bo Ko t CT : : : : : : : : : : : : : 44 4 1,5 1,75 40,4 2 16 2,0 9,3 24,9 2,0 0,35 38,0 0,3 0,1 + 0,1 0,1 0,1 0,15 0,1 0,1 0,1 0,1 0,05 0,1 pull off direction X-X Po Do P1 P2 t X Ko D1 Ao view direction X SPEC-Gurt 0061/ 19X6,5 Q09016:02.001 Jul.10,01 W2 Reel (all dimensions in mm): A W1 W2(max) N(min) C : : : : : 330 44,4 + 2/-0 50,4 100 13,0 +0,5 / -0,2 C A N W1 The minimum bending radius is 45 mm. The mounting surface of the filters faces the bottom side of the embossed carrier tape. The marking of the filters is able to read if the view is directed on the upper side of the carrier tape in the above shown direction. VI TELEFILTER Potsdamer Strae 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: tft@telefilter.com Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: vti@vtinh.com VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS 44E.doc Version 1.1 22.03.2002 VI TELEFILTER Filter specification TFS 44E 4/5 6. Air reflow temperature conditions : 1st and 2nd air reflow profile Name: Temperature: Time: pre-heating periods 150 C - 170 C 60 sec. - 90 sec. main-heating periods over 200 C 20 sec. - 25 sec. peak temperature 255 C 5 C Chip-mount air reflow profile 260 240 220 200 180 temperature / C 160 140 120 100 80 60 40 20 0 0 20 40 60 80 100 120 time / sec. 140 160 180 200 220 240 Table for temperature vs. time during the air reflow process Tolerance of temperatures: 5 C time / sec. 0 10 20 30 40 50 60 70 80 90 100 110 120 130 temperature / C 23 34 46 60 80 103 121 134 143 150 154 156 158 159 time / sec. 140 150 160 170 180 190 195 200 205 210 215 220 230 240 temperature / C 160 161 164 170 180 205 230 255 230 205 180 165 140 120 VI TELEFILTER Potsdamer Strae 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: tft@telefilter.com Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: vti@vtinh.com VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. TFS 44E.doc Version 1.1 22.03.2002 VI TELEFILTER Filter specification TFS 44E 5/5 7. History : Version 1.0 1.1 Reason of Changes - generate development specification according to customer requirements. - generate filter specification. - add 40 dB limit lines; - add typical values. Name Dunzow W. Dunzow W. Date 30.10.2001 22.03.2002 VI TELEFILTER Potsdamer Strae 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: tft@telefilter.com Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: vti@vtinh.com VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. |
Price & Availability of TFS44E |
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
[Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |